2007 Ic Bus CeCE SERIES SCHOOL

Navistar, Inc. is recalling certain model year 2007-2015 IC BE and CE school buses, 2013-2015 IC AE school buses, 2007-2011 IC FE school buses, and 2007-2014 IC RE school buses equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts by Ricon. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2007-2012 IC CE AND BE SCHOOL BUSES MANUFACTURED FROM JUNE 27, 2006, THROUGH MARCH 23, 2011, EQUIPPED WITH A MAXXFORCE 7 ENGINE FEATURE CODE 12NTH, 12NTD, 12NTE, 12NTG, 12VYY, OR 12627 AND ALTERNATOR FEATURE CODE 0008GGR, 0008GGM, 0008GWX, OR 0008GEL. THE POSITIVE ALTERNATOR CABLE MAY RUB ON THE ENGINE CONTROL MODULE MOUNTING BRACKET, POSSIBLY CHAFING ITS INSULATION AND CAUSING AN ELECTRICAL SHORT.

NAVISTAR IS RECALLING 61,316 MY 2001 THROUGH 2009 IC BE, CE, AND FE MODEL COMMERCIAL AND SCHOOL BUSES MANUFACTURED BETWEEN FEBRUARY 2, 2000 AND JUNE 2, 2008, EQUIPPED WITH AN ENTRANCE DOOR STEPWELL HEATER FEATURE CODE 0048PMS OR 0548001 AND/OR A REAR WALL MOUNTED HEATER FEATURE CODE 0048TAR OR 0048PSX. THE AFFECTED HEATER UNITS MAY FAIL IN LOW SPEED OPERATION CAUSING ELEVATED TEMPERATURES.

NAVISTAR IS RECALLING 24,975 MY 2003 THROUGH 2008 IC BE, CE, HC, AND RE SCHOOL AND COMMERCIAL BUSES AND 2002 THROUGH 2008 INTERNATIONAL 3200 AND 3300 MODEL BUSES MANUFACTURED BETWEEN SEPTEMBER 21, 2001 THROUGH DECEMBER 14, 2007, EQUIPPED WITH INTERNATIONAL VT365 ENGINES. THESE VEHICLES MAY EXHIBIT ENGINE HARD START, NO START, OR STALL CONDITIONS DUE TO POSSIBLY DAMAGED TERMINALS IN THE FUSE HOLDER CONNECTOR OF THE INJECTOR DRIVE MODULE (IDM) CLEAN BATTERY POWER CIRCUITS. THE TERMINALS MAY HAVE BEEN DAMAGED DURING ELECTRICAL CONTINUITY TESTING IN THE MANUFACTURING PROCESS.

NAVISTAR HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2010 AND 2011 IC CE, BE, AND FE SCHOOL BUSES MANUFACTURED FROM NOVEMBER 19, 2003 THROUGH FEBRUARY 9, 2010. THE PARKING BRAKE MAY RELEASE IF THE BRAKE SYSTEM ELECTRONIC CONTROL UNIT SOFTWARE MISINTERPRETS INPUT SIGNALS GENERATED FROM CYCLING THE IGNITION SWITCH MORE THAN ONCE AT A SPECIFIC FREQUENCY.

NAVISTAR IS RECALLING 51,588 HEAVY TRUCKS, COMMERCIAL BUSES AND SCHOOL BUSES MANUFACTURED BETWEEN NOVEMBER 21, 2000 AND MAY 21, 2008, EQUIPPED WITH ONE OR MORE REMOTE POWER MODULES. THE POTTING MATERIAL THAT ENCAPSULATES THE CIRCUIT BOARD OF THE VEHICLE'S REMOTE POWER MODULE MAY NOT SUFFICIENTLY SEAL THE CIRCUIT BOARD FROM WATER AND CONTAMINATION INTRUSION. IF THE ENCAPSULATION IS COMPROMISED, WATER AND CONTAMINANTS MAY CAUSE AN INTERNAL ELECTRICAL SHORT, POSSIBLY RESULTING IN A FIRE.